Jaguar Forums - Jaguar Enthusiasts Forum
0 2020/11/24 02:24:45
0 2020/11/24 02:24:51
0 2020/11/24 02:24:56
0 2020/11/24 02:27:53
0 2020/11/24 02:27:58
0 2020/11/24 02:28:03
0 2020/11/24 02:28:07
0 2020/11/24 02:28:12
0 2020/11/24 02:28:17
0 2020/11/24 02:28:21
0 2020/11/24 02:28:24
0 2020/11/24 02:28:27
0 2020/11/24 02:28:32
0 2020/11/24 02:28:38
0 2020/11/24 02:28:42
0 2020/11/24 02:28:45
0 2020/11/24 02:28:49
0 2020/11/24 02:28:54
0 2020/11/24 02:28:59
0 2020/11/24 02:29:04
Obvious horizontal gap where foam once lived between plastic air box and lower windscreen. Smaller vertical gap against firewall is visible as well.
Obvious horizontal gap where foam once lived between plastic air box and lower windscreen. Smaller vertical gap against firewall is visible as well.
0 2020/12/06 06:10:09
0 2020/12/06 06:13:17
New foam in place but still a small gap visible against the firewall and needed another strip.
New foam in place but still a small gap visible against the firewall and needed another strip.
0 2020/12/06 06:14:56
Air box out of vehicle. Old foam completely deteriorated but double sided tape which must that held it in place still present. Take note of where all old foam was factory positioned and measure protrusion when renewing.
Air box out of vehicle. Old foam completely deteriorated but double sided tape which must that held it in place still present. Take note of where all old foam was factory positioned and measure protrusion when renewing.
0 2020/12/06 06:17:48
Foam protrusion shown vertically here needs to be tucked down and in the LHS hole visible here.
Foam protrusion shown vertically here needs to be tucked down and in the LHS hole visible here.
0 2020/12/06 06:17:59
Old (protruding) foam that should have been tucked down and in completely gone but adhesive tape still present. Take note and measure the length.
Old (protruding) foam that should have been tucked down and in completely gone but adhesive tape still present. Take note and measure the length.
0 2020/12/06 06:26:25
Air box rubber seal shown will go the distance but foam needs replacing. Air box firewall side shown.
Air box rubber seal shown will go the distance but foam needs replacing. Air box firewall side shown.
0 2020/12/06 06:26:33
Lower windscreen finisher underneath air box side shown. Renewed in superior insulation.
Lower windscreen finisher underneath air box side shown. Renewed in superior insulation.
0 2020/12/06 06:26:41
0 2020/12/15 16:18:08
Ripped front bumper undertray that was Flapping around
Ripped front bumper undertray that was Flapping around
0 2021/02/03 00:40:46
18 years worth of different leaking oils, road grime and soil.
18 years worth of different leaking oils, road grime and soil.
0 2021/02/03 00:41:03
Evidence on the right of leaking compressor oil (green dye). Red liquid is when I did not follow proper Workshop Manual procedure of draining the supercharger radiator properly through its drain plug; I let it pour out of the house.. NASA style duct that directs air to a vent that cools the alternator.
Evidence on the right of leaking compressor oil (green dye). Red liquid is when I did not follow proper Workshop Manual procedure of draining the supercharger radiator properly through its drain plug; I let it pour out of the house.. NASA style duct that directs air to a vent that cools the alternator.
0 2021/02/03 00:41:22
Closer look of insulation pad with evidence of where it presses on the crossmember and most of its protective plastic coating having perished.
Closer look of insulation pad with evidence of where it presses on the crossmember and most of its protective plastic coating having perished.
0 2021/02/03 00:41:40
Bottom view before cleaning both sides which wasn't much fun. I scaped off about a kilo of crud!
Bottom view before cleaning both sides which wasn't much fun. I scaped off about a kilo of crud!
0 2021/02/03 00:42:03
Cleaned tray with secured firewall material ILO factory foam pad.
Cleaned tray with secured firewall material ILO factory foam pad.
0 2021/02/03 00:42:19
Reinforcement repair shown which stopped tray bending and cracking further.
Reinforcement repair shown which stopped tray bending and cracking further.
0 2021/02/03 00:42:29
Bit of right angle aluminium cut to size.
Bit of right angle aluminium cut to size.
0 2021/02/03 00:42:40
Another reinforcement repair on other side.
Another reinforcement repair on other side.
0 2021/02/03 00:42:51
The other side only needed 3 bolts to hold it in place.
The other side only needed 3 bolts to hold it in place.
0 2021/02/03 00:43:01
Similar repair on the front bumper undertray, which had to hold the factory washer.
Similar repair on the front bumper undertray, which had to hold the factory washer.
0 2021/02/03 00:43:12