Jaguar Forums - Jaguar Enthusiasts Forum
tranny mount with tell-tale crumble signs ...
tranny mount with tell-tale crumble signs ...
0 2016/10/06 08:54:52
full-on foam buffer crumble, zero buffer remaining
full-on foam buffer crumble, zero buffer remaining
0 2016/10/06 08:54:57
bottom centre bucket mount sheared off
bottom centre bucket mount sheared off
0 2016/11/19 21:50:36
luckily one or two threads left so I could get the correct angle for repair
luckily one or two threads left so I could get the correct angle for repair
0 2016/11/19 21:51:33
This stuff sets rock hard and is usually used for porcelain repair
This stuff sets rock hard and is usually used for porcelain repair
0 2016/11/19 21:59:23
Water based putty can be molded with wet tools
Water based putty can be molded with wet tools
0 2016/11/19 21:59:44
Always leave a bit of putty on the side to test for set-up hardness - in this case after about 3 hours it was hard but not too hard to trim with a sharp razor-knife.
Always leave a bit of putty on the side to test for set-up hardness - in this case after about 3 hours it was hard but not too hard to trim with a sharp razor-knife.
0 2016/11/19 21:59:59
Mounting the replacement bucket
Mounting the replacement bucket
0 2016/11/19 22:07:09
Repaired unit ready to install in the car.
Repaired unit ready to install in the car.
0 2016/11/19 22:08:11
0 2016/12/29 00:23:18
rear side of plenum
rear side of plenum
0 2016/12/30 15:39:03
plenum crevice - drain to duckbill at far left - foam washer wire insulation upper left. Whole area clean with no rust evident.
plenum crevice - drain to duckbill at far left - foam washer wire insulation upper left. Whole area clean with no rust evident.
0 2016/12/30 15:39:11
Windscreen corner with plastic plenum cover removed. Clean.
Windscreen corner with plastic plenum cover removed. Clean.
0 2016/12/30 15:46:50
Windscreen seal quite slack at this corner ..could this be the entry point?
Windscreen seal quite slack at this corner ..could this be the entry point?
0 2016/12/30 15:46:56
Sunroof drain tube (cut short) upper rt ..wiring harness apertures at left.
Sunroof drain tube (cut short) upper rt ..wiring harness apertures at left.
0 2017/01/10 18:21:22
Traces of moisture here
Traces of moisture here
0 2017/01/10 18:29:14
0 2017/01/10 18:44:54
A better view of the "wet spot" and a silt deposit that runs down the harness
A better view of the "wet spot" and a silt deposit that runs down the harness
0 2017/01/10 18:48:45
General condition of inner wing
General condition of inner wing
0 2017/01/10 18:48:52
Silt on harness directly below drain channel guide
Silt on harness directly below drain channel guide
0 2017/01/10 18:48:59
Too cold to pour water so have to wait till it warms up to examine area again
Too cold to pour water so have to wait till it warms up to examine area again
0 2017/01/10 18:49:09
0 2017/01/10 18:56:05
0 2017/01/10 18:56:15
0 2017/01/10 18:56:21
0 2017/01/10 18:56:30
You were saying ...
You were saying ...
0 2017/02/10 15:56:49
0 2017/02/14 09:24:04
5" leaper previously dealer fitted to an '88 XJ40
5" leaper previously dealer fitted to an '88 XJ40
0 2017/02/15 16:24:06
0 2017/02/28 09:01:12
bamboo stick, split, paper towels impaled!
bamboo stick, split, paper towels impaled!
0 2017/03/20 19:20:34
moisture build-up at left corner of lens
moisture build-up at left corner of lens
0 2017/03/20 19:22:07
annoying steam-up inside headlight
annoying steam-up inside headlight
0 2017/03/20 19:22:15
two sheets folded together and inserted into the split bamboo - good grip!
two sheets folded together and inserted into the split bamboo - good grip!
0 2017/03/20 19:23:47
"screwing" the paper towel mop into the headlamp through the bulb aperture
"screwing" the paper towel mop into the headlamp through the bulb aperture
0 2017/03/20 19:30:07
"screwing" the paper mop into the headlight through the bulb aperture
"screwing" the paper mop into the headlight through the bulb aperture
0 2017/03/20 19:31:23
0 2017/03/20 19:35:29
mopping up!
mopping up!
0 2017/03/20 19:39:04
reefing out the old caulk to make room for the new stuff; lens masked off to avoid slop.
reefing out the old caulk to make room for the new stuff; lens masked off to avoid slop.
0 2017/03/20 19:41:25
New caulk applied.
New caulk applied.
0 2017/03/20 19:43:51
Used this silicone for the seal, could have gone for different stuff, but this was on hand and looked like it would be good enough.
Used this silicone for the seal, could have gone for different stuff, but this was on hand and looked like it would be good enough.
0 2017/03/20 19:46:07